Perform a voltmeter test to determine the state of charge. Tighten the Allen head capscrew to 3035 ftlbs 40. Route main positive battery cable through holders on electrical bracket. Operation is subject to the following two conditions: 1 This device may not cause harmful interference, and 2 This device must accept any interference received, including interference that may cause undesired operation. The horn is operated by pushing on the horn switch 2 located on the left handlebar control group. With hundreds of pages, it will show you how to distinguish any problem from an oil change to a transmission swap and how to fix it on your own. Do not fill above bottom of filler neck insert, leaving air space for fuel expansion.
See Starting the Engine: Sportster Models for detailed operation procedures. Pay strict attention to whether the road is dry, oily, icy or wet. Use caution when judging the size or relative distance of objects seen in rear view mirrors. Riding with excessively worn, unbalanced or underinflated tires can adversely affect stability and handling, which could result in death or serious injury. Doing so could cause a spark and explosion, which could result in death or serious injury.
Unhook battery strap from battery tray mount on top of battery and remove strap. See a HarleyDavidson dealer for service. Improper brake operation could result in death or serious injury. Wear safety glasses when working with compressed air. If applicable, inspect passenger strap for damage or excessive wear.
Charge the battery every month if stored at temperatures below 60° F 16° C. After parking your motorcycle, lock the steering head and remove ignition key from switch. This alarm cycle will be repeated ten times if the siren is in the selfdriven mode. Selfdischarge is a normal condition and occurs continuously. Press top of side cover into clips until snug. Check tire condition and pressure. Do not fill fuel tank above the bottom of the filler neck insert.
The display will switch to the time display with the hours blinking. Refer to Recommended Engine Oils. Keep open flames, electrical sparks and smoking materials away from battery at all times. Removing Motorcycle From Storage The clutch failing to disengage can cause loss of control, which could result in death or serious injury. Tighten screws in a crosswise pattern to 84108 inlbs 9.
Primary chain inspection cover Primary Cover: 2007 Sportster Models Changing Lubricant 1. Air Cleaner See Air Cleaner Assembly: Sportster Models. Slowly turn a thin blade in the thumbnail slot 1 on the side of the fob to separate the two halves. Charge battery in a wellventilated area. The fourway flashers will continue for two hours.
Install screw and fasten seat mounting bracket to top of rear fender. Be sure headlamp is on at all times. Even with the engine running and the motorcycle standing still, difficulty may be experienced in shifting gears. Service Departments When the motorcycle is to be left at a HarleyDavidson dealer, there are two options: 1. Five indicator lamps are provided. Lift the gear shift lever up to the end of its travel and release.
The speedometer registers miles per hour U. With negative cable disconnected from grounding point on crankcase, insert bolt through MaxiFuse cable first then through main battery positive cable + red and into threaded. To start forward motion, ease out the clutch lever slowly and at the same time, open throttle gradually. Refer to Primary Chain Adjustment: Sportster Models. Front Fork Bearings Adjustments to front fork bearings should be performed by. Troubleshooting Key Icon If the system key icon stays illuminated while riding, see a HarleyDavidson dealer. Clutch Hand Lever Do not position fingers between hand control lever and handlebar grip.