Does the fan come on when the car is first started when engine is cold? The vehicle was taken to a mechanic, who stated that this was a common complaint for this type of vehicle. This needs to be a recall issue that Chevrolet fixes without charging its customers!!!. Nothing I could demonstrate to the service department. But to no avail, I cannot find any recalls from chevrolet about their many faulty parts. Lowest price on brand new, in-the-box auto parts. The fan clutch is responsible for pushing radiator fluid through the water pump, which keeps the engine cool. Because of this, I had to drive below the speed limit for over 50 miles for fear of my truck blowing up.
I have copies of at least a thousand internet complaints with the first one posted around November 2001 --- just about the time we purchased the vehicle new. The last time it would not go off so I took it in and they told me it was the cooling fan motor. I have had this fan replaced three times now and am not at all pleased that this vehicle has not been recalled for this problem. You are right about trying to fix the problem which I thought I did. Although this installation is a challenging process, following the instructions that come from a repair manual such as the Haynes manual can make the process a lot easier. I have no check engine lights.
This weekend, it began sounding like it is struggling to accelerate. If the fan clutch gets stuck in the engaged position, which is not uncommon, it will cause the fans to fully engage even when it is not desirable for them to be on. I was merging onto a highway and couldn't get the engine over 30 miles per hour. I will be asking for the old component. Matched set for this vehicles application. The failure mileage was 78903 and current mileage is 94,000.
Coolant Leak How To Replace The Water Pump On A Gm Chevy 4 3 Liter Is there a trick to remove the fan cluth from water pump on best loaner fan clutch wrench parts for cars trucks suvs how to remove a fan clutch in under 15 minutes oem fan clutch service set 27224 how to change water pump on 2003 chevy trailblazer 2 3l. I will be asking for the old component. The manufacturer stated that there were no recalls and could only make a note of the failures. You are trying to fix the results of a problem but you need to find the problem. Right before this constant jet plane sound started, the battery blew up. A faulty fan clutch that leaves the fan permanently engaged will not only cause a noisy engine, but can also cause a decrease in performance.
Replaces and restores engine cooling power components. The noise is intermittent and the periodic rate is constant regardless of engine speed rpm's. I cannot believe gm has not issued a recall for this issue. One morning it just began operating at a high rate when I started my vehicle and as stated, continued for serveral minutes. AutoTrust Platinum provides a growing selection of low-priced radiators, fans, cooling systems and components. It appears that thousands of owners are having the same problems and have been for years but there is still no recall. In the event this item should fail due to manufacturing defects during intended use, we will replace the part free of charge excludes shipping charges for the original purchaser.
When I took the vehicle to my mechanic I was told the cooling fan clutch assemble had failed. The fan operates at 100% due to the fan clutch failing resulting in loss of power. Please contact us before modifying the part so that we have the opportunity to correct the situation. This vehicle only has 35,000 miles. While under warranty was told by dealer that the noise was normal and that there were no problems.
With the fluid drained, tighten the drain plug with the needle-nose pliers. Took the vehicle to a dealer and confirmed the fan clutch had failed. A malfunctioning fan clutch can cause the engine to overheat because of poorly circulating radiator fluid. Usually a will produce a few symptoms that can alert the driver of a potential issue. In the event a manufacturing defect is found, the item may be eligible for an exchange. Complaint Number: 10176192 Incident Date: December 14, 2006 Date Added to File: December 14, 2006 Description of the Complaint: Fan clutch failed on vehicle that is only 3 years old. This is my first and last gm product!!!! The contact stated that the fan clutch was failing and sounded like a plane taking off when pressure was applied to the accelerator pedal.
Complaint Number: 10222193 Incident Date: March 22, 2008 Date Added to File: March 24, 2008 Description of the Complaint: For approx. Replaces and restores engine cooling power components. I have not tested the temp sensor. Since I am unable to get up to highway speeds, I feel I am a safety hazard to other drivers that must slow down until they can pass or I get up to proper highway speeds. The vehicle does not shift properly during this period of time.